MATERIAL
SAFETY DATA SHEET
Product
Name: OzzyJuice® SW-1 Activating Degreasing Solution
Product Use: Degreasing
Fluid for the SmartWasher system
SECTION II
HAZARDOUS INGREDIENTS / INFORMATION
HAZARDOUS |
% |
CAS # |
LD50 OF INGREDIENTS |
LC50 OF INGREDIENT |
INGREDIENTS |
|
NUMBER |
(SPECIES & ROUTE) |
(SPECIES & ROUTE) |
|
|
|
|
|
Non Hazardous proprietary
water based degreaser |
100 |
N/A |
N/A |
N/A |
All ingredients are
listed on the TSCA Chemical Substance Inventory and on the Domestic Substance
List |
|
|
|
|
|
|
|
|
|
SECTION III
HAZARDS IDENTIFICATION
UN Number: Not Required
Dangerous Goods
Classification: Non Hazardous
hazard ratings (nfpa/hmis)
health 1 0 = least
1 = slight
flammability 0 2 = moderate
3 = high
reactivity 0
4 = extreme.
SECTION IV
PHYSICAL / CHEMICAL CHARACTERISTICS
BOILING POINT: 210o F/99o C PH: 7.0
APPEARANCE AND ODOR : Clear, low odor fluid
VOC Content: < 5 g/L
VOC composite partial
pressure: < 1 mm Hg
Product
Name: OzzyJuice® SW-1 Activating Degreasing
Solution PAGE 2 OF 3
SECTION V
FIRST AID MEASURES
EMERGENCY & FIRST AID
PROCEDURES:
EYES: It is
unlikely that emergency treatment will be required; if adverse effects occur,
rinse eyes with large amounts of water until no evidence of chemical
remains. Seek medical attention if
necessary.
SKIN: It is
unlikely that emergency treatment will be required; if adverse effects occur,
rinse affected area with large amounts of water until no evidence of chemical
remains. Seek medical attention if
necessary.
INGESTION: It
is unlikely that emergency treatment will be required; if adverse effects
occur, treat symptomatically and seek medical attention if necessary.
INHALATION: It
is unlikely that emergency treatment will be required; if adverse effects
occur, remove to fresh air and observe.
Seek medical attention if necessary.
SECTION VI
FIRE & EXPLOSION HAZARD DATA
FLAMMABILITY: None
MEANS OF EXTINCTION: N/A
FLASH POINT : None > 200 F METHOD
USED : Open cup
FLAMMABLE LIMITS :
UPPER : None
LOWER : None
SPECIAL FIRE FIGHTING
PROCEDURES : None
USUAL FIRE & EXPLOSION
HAZARDS : None
SECTION VII
ACCIDENTAL RELEASE MEASURES
In the event that this
material is released or spilled, it can be washed into storm sewer with large
quantities of water.
SECTION VIII
HANDLING, STORAGE & TRANSPORT INFORMATION
No special precautions are
required. This product is not hazardous
for storage and transport according to the
SECTION IX
EXPOSURE CONTROLS
Exposure Limits: This product
presents no health hazards to the user when used according to label directions
for its intended purposes.
VENTILATION (Local exhaust) : Not required.
SECTION X
PERSONAL PROTECTION
RESPIRATORY PROTECTION
(Specify Type) : Not required.
PROTECTIVE GLOVES : It is recommended that rubber gloves be
worn when
handling any industrial-use products.
EYE PROTECTION : It is recommended that safety
glasses be worn when
handling any industrial-use products.
OTHER / HYGIENIC PRACTICES :
Always use good housekeeping procedures when
using any chemical product.
Product
Name: OzzyJuice® SW-1 Activating Degreasing
Solution PAGE 3 OF 3
SECTION XI
STABILITY AND REACTIVITY DATA
REACTIVITY: Non reactive
STABILITY : Stable
HAZARDOUS POLYMERIZATION
: Will not occur
ROUTES OF ENTRY: Skin, Eyes
EFFECTS OF ACUTE EXPOSURE: It
is unlikely that exposure will require treatment because product is considered
a dermal non-
irritant and a mild ocular
irritant.
HEALTH HAZARDS (Acute &
Chronic) : None
CARCINOGENICITY : None Known
TETRATOGENICITY: None known
BIODEGRADABILITY : Biodegradable
TOXICITY INFORMATION:
48 hours LC50 value in mg/L
Ceriodaphnia dubia 177
mg/L
Fathead Minnows 367
mg/L
SECTION XIV
DISPOSAL CONSIDERATIONS
WASTE DISPOSAL: This product
is a water soluble and biodegradable fluid that will not harm sewage-treatment
organisms if disposal by sewer or drain is necessary. Dispose of in accordance with Local, State and Federal
regulations.
SECTION XV
ADDITIONAL INFORMATION