MATERIAL
SAFETY DATA SHEET
Product
Name: Defoamer
(Additive)
Product Use: Metalworking
Defoamer for the SmartWasher system
SECTION II
HAZARDOUS INGREDIENTS / INFORMATION
Hazardous
Ingredients: This material has no known
hazards under applicable laws.
SECTION III
HAZARDS IDENTIFICATION
Principle Hazards: This material has no known hazards.
Dangerous Goods
Classification: Non Hazardous
hazard ratings (nfpa/hmis)
health 0 0 = least
1 = slight
flammability 0 2 = moderate
3 = high
reactivity 0
4 = extreme.
SECTION IV
PHYSICAL / CHEMICAL CHARACTERISTICS
APPEARANCE AND ODOR: Milky white liquid/Mild odor
SOLUBILITY IN WATER: Water dispersible
SPECIFIC GRAVITY: 1 (15.6ºC)
BOILING POINT: 100ºC, 212ºF (Typical)
POUR POINT TEMPERATURE: 33 ºC, 91ºF
FREEZING POINT: 0ºC, 32ºF
VAPOR PRESSURE: 18mm Hg (20ºC)
pH: 7.0
SECTION V
FIRST AID MEASURES
EMERGENCY & FIRST AID
PROCEDURES:
EYES: Flush with water at least 15 minutes. Get medical attention if eye irritation
develops or persists.
SKIN: It is unlikely that emergency treatment will
be required; if adverse effects occur, rinse affected area with large amounts
of water until no evidence of chemical remains.
Seek medical attention if necessary.
INGESTION: DO NOT INDUCE VOMITING. Give 2 glasses of water. Get immediate medical attention.
INHALATION: Remover exposed person to fresh air if
adverse effects are observed.
Product
Name: Defoamer
(Additive) PAGE 2 OF 3
SECTION VI
FIRE & EXPLOSION HAZARD DATA
FLAMMABILITY: Material does not have explosive properties.
MEANS OF EXTINCTION: N/A
FLASH POINT: Not Applicable
SPECIAL FIRE FIGHTING
PROCEDURES: None
USUAL FIRE & EXPLOSION
HAZARDS: None
SECTION VII
ACCIDENTAL RELEASE MEASURES
Not Applicable.
SECTION VIII
HANDLING, STORAGE & TRANSPORT INFORMATION
ICAO/IATA: Not Regulated. No special precautions are required.
SECTION IX
EXPOSURE CONTROLS
EXPOSURE LIMITS: This product
presents no health hazards to the user when used according to label directions
for its intended purposes.
VENTILATION (Local
exhaust): Not required.
SECTION X
PERSONAL PROTECTION
RESPIRATORY PROTECTION
(Specify Type): Not required.
PROTECTIVE GLOVES: It is recommended that rubber gloves be worn when
handling any
industrial-use products.
EYE PROTECTION: It is recommended that safety glasses be worn
when handling any industrial-use products.
OTHER / HYGIENIC PRACTICES: Always use good housekeeping procedures when
using any chemical product.
SECTION XI
STABILITY AND REACTIVITY DATA
REACTIVITY: Non reactive
STABILITY: Stable
HAZARDOUS POLYMERIZATION: Will not occur
EYE TOXICITY: Not expected to cause eye irritation.
SKIN TOXICITY: Not expected to be a primary skin
irritant. Prolonged or repeated skin
contact may cause dermatitis.
INHALATION TOXICITY: Not expected to be a toxic inhalation hazard.
HEALTH HAZARDS (Acute &
Chronic): None known.
CARCINOGENICITY: None known
TETRATOGENICITY: None known
Product
Name: Defoamer
(Additive) PAGE 3 OF 3
BIODEGRADABILITY: Not determined.
BIOACCUMULATION: 25% or greater of the components display no
potential to bioconcentrate.
TOXICITY INFORMATION:
48 hours LC50 value in mg/L
Rats (oral) >5000
mg/Kg
Rabbits (dermal) >2000
mg/Kg
SECTION XIV
DISPOSAL CONSIDERATIONS
WASTE DISPOSAL: Not applicable.
SECTION XV
ADDITIONAL INFORMATION